WagnerSpraytech 0529091 FLEXiO 5000 Stationary HVLP Paint Sprayer, Sprays Unthinned Latex & C900038.M Large Spray Shelter with Built-in Floor & Screen, Portable Paint Booth for DIY Spray Painting

Bought this to paint some stone because using a brush and roller just took forever and used a lot of paint with this I used 2 gallons versus the 6 gallons it takes with a roller and brush only had one issue and it was my fault I started the blower and was going along and it quit I thought I blew a breaker so went to check but what happened was I had bumped the switch on the handle when I twisted my hand while spraying so when I bumped the switch it partial engaging shutting of the machine so be careful if it shuts off check that switch on the handle if it’s partially engaged it will shut off doesn’t take much so be careful cleans up with warm water other than my screw up no problems tomorrow painting the concrete block around bottom of house tomorrow to me it goes faster less paint does the job so much easier so I can get on to other things made my life easier

Ok, so I put this off long enough, in the end it does the job that you will want when it comes to painting and it will do it fairly quick. However, it is very finicky. Maybe it is me because I am a novice at painting but it over sprayed often. You will take more time taping off the things you do not want painted than it will take to paint with the system.If you are not painting high areas you will not need the longer hose it will get in your way, I stepped on the hose no short 50 times in about three days.Also be advised the sprayers have seals that you cannot lose, if you do the sprayer will no longer work correctly, I believe this is what happened to other people because it happened to me and now I cannot use the finisher sprayer.In addition I found leaving the top to the blower open works very well when using it more than 30 mins at a time. If not the blower air will get hot and dry the paint as it is being sprayed which will in turn clog up the sprayer.Finally, if you use the sprayer immediately clean it, I found this works when dealing with clogging. It does not take that long once you familiarize your self with the parts you will see which needs to be cleaned the most which are the tip of the sprayers and the holes that blow the air.All in all, it does it’s job the instructions could be better and explain how to actually clean the system, but it will do the job.

Mainly using the FLEXiO 570 for primer. Says it will spray unthinned but I have been thinning the Killz and Zinsser primers about 10%.With a little adjusting of the few settings it has, it will lay out the primer well enough to where it will flow out pretty flat. I am used to years of painting automobiles and the more adjustability of automotive type spray guns.I am also used to being able to point a spray gun downward as if I am spraying a horizontal panel. This sprayer is not supposed to be aimed over 45 degrees as paint may fill a tube on the side of the spray gun.And unlike with the constant air you have with an automotive spray gun, this makes the air with the electric motor attached to the back of the spray gun. So when its shut off, there is no air. Must remember to pull the trigger partly for a short moment to get the electric air pressure built up before pulling the trigger further for paint flow. You can hear when the turbine is up to speed and ready to spray.I partially like the sprayer as I wanted my primers to lay out flatter. But with the spray, 100% does not get on the surface being painted. So you will use more material as opposed to using a roller or brush.

UPDATETried the painter again today, but this time made sure to keep the spray tip cleaned all the time; wiping it with a damp cloth. This time it worked well; so I am revising my rating from 1 star to 3“Worked well with the first load of paint, but subsequently would clog between refills.I definitely regret buying this equipment; painting with a roller or brush is more time consuming, but at least it gets the job done with zero hassle and much less mess to boot.”

Call me skeptical then impressed. They really improved this machine over the last decade. I just sprayed five interior doors dark navy blue and didn't have to thin the primer or the paint. Zinger 123 in grey and Glidden Diamond. Going from builder white to navy was a four coat process, two each, but it was fantastic when done. I also sprayed the entire hall area in a white that was ship lapped. Got in the cracks perfectly. I usually spray interior of houses with a Grayco Magnum airless but that was way too big and powerful for what I needed done on this job. Cleanup of the Wagner was easy peasy with a touch of fabric softener in the water and then a clear rinse.

Got this to pain ceilings in new home - without a doubt has saved so much time over rolling and not a single issue or problem

So now that i have used this a few times I find it very nice. It's not a rugged built machine that you can just toss around though. Very much plastic so taking care of it will make your life easier. It sprays nice and have not had a clogging problem at all. Make sure to clean well after use and your good to go. Only down fall is the hose length. Would be nice if it was 10 more feet so not having to go back and move unit. 10x20 shed start to finish no problemsEdit updateAfter my first project and a good cleaning I pull this out again and was pleased that no clogs and worked great for me again. Moat important thing is to clean all parts when project is complete.

works good now will not be returning

The product works reasonably as advertised although when using latex paints, even when cleaning the head regularly, at times you will get splattering from the nozzle. I painted a whole room, ceiling first and then the walls and trim. Honestly, the prep time to mask everything you don’t want painted, far out weighs the time to paint the old fashioned way, brush and roller. If prep materials where available to shorten the time it would be worth considering as it does a reasonable job. All in all, for certain projects, it may be the right tool. On the design side, I found the switch turned on too easily, especially when you didn’t want it to due to the location on the unit. Further a recommendation would be to include a guide to indicate how much product is left in the container rather than having to guess.

Great sprayer! I have tried several as I spray furniture regularly.I found this easy to use and did a great job.My only complaint was it died within 4 months of use. I was so disappointed. To find one I really liked, but it didn’t last.I have no idea what happened.The parts(filters) are hard to find and order.I’d recommend, but beware it may only last a few months. Depends on what you need it for. Long term wise, it may not last. But for a big project, I’d definitely recommend. It finishes cabinets beautifully.

I’m hoping I just got a defective item and have ordered a replacement, but the first one had multiple issues. The screw lid on the bottle did not sit flush even before use, it wouldn’t work once paint was in the bottle until I had to use excessive force with my friend and I getting it aligned, it then worked intermittently and finally just became ridiculous as if it was spitting non stop. The final removal of the bottle caused a bad cut to my right wrist over a surgery scar which is now causing nerve pain. And I’m left with a half painted porch. Amazing day. Let’s hope the next one shows signs of being functional before use otherwise it is going back. On the positive side of things, the instructions were very clear.

This would be a much better product if the little ring that needs replacement is readily available . They wear out fast and then it does a crappy job f. You will pay more in shipping than the part is worth and good luck finding them in the stores that even carry this product . If it were not for that I would give it four stars , but those rings wear fast .

Nice product. Paint spray flow good without blobs. Takes a bit to get used to motion and distance from item to be painted to get good even coverage. Helpful to practice on spare wood. Really easy to clean. Some overspray but again, more likely my technique. Would buy again.